ESYB Green 20A 3000mAh 18650 Bench Test Results...tested as 19A/2900mAh, seems to be HG2

Discussion in 'Batteries and Chargers' started by Mooch, Jun 10, 2016.

Thread Status:
Not open for further replies.
Image has been removed.
URL has been removed.
Email address has been removed.
Media has been removed.
  1. Mooch

    Mooch Electron Wrangler Verified Member ECF Veteran

    Supporting member
    May 13, 2015
    These cells were donated by ESYB for the purposes of testing. Thank you! To prevent any confusion with the eGo-type "batteries", I use the term "cell" here to refer to a single 18350, 18650, 26650, etc.

    While the test results are hard data, the conclusions and recommendations I make based on these tests are only my personal opinion based on my criteria for setting a rating. Carefully research any cell you are considering using before purchasing.

    Testing cells at their limits is dangerous and should never, ever, be attempted by anyone who has not thoroughly studied the dangers involved and how to minimize them.

    If the cell has only one current rating number on it, or if it says "max discharging current" then I have to assume that the company is stating that the cell can be discharged at that current level in any way, including continuously.

    image.jpeg image.jpeg image.jpeg image.jpeg


    Bottom Line
    This ESYB cell appears to be a LG HG2. It looks identical to an HG2 and performs just a bit below, and a bit hotter, than the other HG2's I've tested. This is why I have rated it at 19A/2900mAh. This is very close to the claimed 20A/3000mAh rating though. This cell still has the useless "pulse" rating in large lettering on the wrap but does list both the continuous and pulse current ratings, a very welcome change that's been appearing lately.


    Continuous-Current Test Results
    image.png


    Pulsed-Current Test Results
    image.png image.png


    Comments
    • At 10A continuous it reached a bit more than 2700mAh. This is too low for a 3000mAh cell at 10A so I am rating this cell at 2900mAh.
    • At 15A continuous the temperature rose to 71°C. This is significantly below the average temperature of a cell running at its continuous discharge rating (CDR).
    • At 20A continuous the temperature rose to 87°C. This is a few degrees above the average temperature of a cell running at its CDR and is an indication that we are just past the cell's true rating.
    • At 25A continuous the temperature rose to 102°C. This is a ridiculously high temperature and is above my 100°C safety limit.
    • I am setting a CDR of 19A for this cell. Operating at that level would bring the temperature up to the average for a LG cell operating at its CDR (about 83°C). While operating any cell near its rated maximum current level causes damage, I would expect decent cycle life from this cell at 19A continuous.
    • I have included pulsed discharges but I haven't set pass/fail standards for pulse testing yet. The discharges were done at 5sec on/30sec off, down to 2.5V. One chart shows the entire discharge at each level. The other chart is zoomed in to show the first 5 minutes to make it easier to see the voltage sag at different current levels.
    To see how other cells have tested and how hard you can safely push them, check out these links:
    List of Battery Tests | E-Cigarette Forum
    18350 Safety Grades and Pulse Performance Data | E-Cigarette Forum
    18650 Battery Ratings -- Picking a Safe Battery to Vape With | E-Cigarette Forum
    26650 Safety Grades and Pulse Performance Data | E-Cigarette Forum
     
    MikeyConti and sonicbomb like this.
  2. sonicbomb

    sonicbomb Vaping Master Verified Member ECF Veteran

    Feb 17, 2015
    1187 Hunterwasser
    An under-performing HG2 under the wrap, hmm I wonder what's the history of those?
     
  3. Agent47

    Agent47 Full Member

    Mar 2, 2012
    Islamabad, PK
    These are most likely grade B and C batteries from LG that failed quality control test and are sold to E.SYB and they re-wrap them.
     
  4. sonicbomb

    sonicbomb Vaping Master Verified Member ECF Veteran

    Feb 17, 2015
    1187 Hunterwasser
    I forgot to add these
    <sarcasm></sarcasm>
     
    Mooch likes this.
  5. Assi

    Assi Multiple ID Suspension

    Jun 2, 2016
    As far as I know, Cells manufacturer like LG don´t sell batteries that are not A-grade into the market. I saw in Germany some batteries (from different manufacturer) with rust on them behind the shrink. In all cases that were older batteries, that have most probably changed some Hands in China and were Held (apperantly) not in good conditions for Li-Ion-Cells (too high moisture etc.)
     
Thread Status:
Not open for further replies.

Share This Page