Hey folks, I'm still banging on this trying to get my aerotanks working better. Rather than just take another blind swing I thought it might help to put out a request for suggestions. I am limited to what I have on hand now, but if getting a good build requires buying some new stuff so be it.
I am working with 28 gauge kanthal A1 right now. I have precision screw drivers at 1.4, 1.5, 2.0, 2.4, and 2.5 mm. Also have drill bits at 1/16 and 3/32. My tanks are aerotank's, so I need to use the bdc style heads. I have a few of the v1 bdc housings that I have been rebuilding - had zero luck pulling the v2 bdc's apart, but I still have a couple of those around and could try to pull them apart again. Stem breaks on me every time I try. The only wicking material I have right now is cotton bacon, and a small bit of rayon that my local B&M tossed into my bag on my last purchase.I think that's about it - that's what I have to work with at this point aside from the obvious bits (pliers, butane torch, wire clippers, ohm reader, etc).
These are the parameters I used for my last build:
Wire: 28 gauge A1 Kanthal from Lightning Vapes
Wick: Cotton Bacon by Wick N' Vape
Tank: Aerotank v2, 2.5ml w/ v3 airflow base
Head: Aerotank/PT3 BDC v1
Mandrel: 1.4 mm screwdriver
Coils: single
Wraps: 10 (I think - I am terrible at remember if I don't write it down at the time)
Resistance: 1.5 ohms
In addition to threading cotton into the coil I also laid a small piece over the top of the coil to help prevent flooding. This build is working, but it's kind of miserable. I am firing the atomizers on an mvp 2.0 and a spinner II. I also have a hana clone I can use to go up to 30 watts, but last time I cooked a wick on the aerotank hitting it with higher wattage on the dna 30 device.
Flavor wise it's not terrible, but I get a lot more flavor from my Taifun. That's to be expected somewhat I suppose. Flavor is not the biggest issue though. The main thing I would like to improve is vapor production. I would say it is performing at or around where a factory coil performs. I have had factory coils work much better than this in fact - some not quite as good. But generally speaking I know I'm doing something wrong here - there must be a lot of room for improvement.
Long post sorry. So do you guys have any suggestions for builds that work well with 28 gauge on the bdc v1's? I was thinking my next try would be to see if a 2mm would work size wise, and try to lose the flavor wick. I also considered going to a dual coil, but I think I need 30 gauge at least for that.
TIA guys. If this doesn't work out I'm probably just going to stick to the rebuildables cause this is about 10x the headache of a Taifun, and seeing as clones of those guys are cheaper then AT's, well - the math works out. But for the sake of getting some use out of my current gear, and MORE for the sake of nailing these builds I would really like to see this come together.